TBG Aircraft Cheesecake - The Messerschmitt 262

JohnL over at TexasBestGrok has his latest installment of Aircraft Cheesecake. This week's installment concerns the strangely attractive Messerschmitt 262.

The Me 262 was the world's first combat-deployed jet fighter, developed during World War II as a strike fighter at the orders of Adolf Hitler. Luckily for the Eighth Air Force's daylight formations of bombers, the Me 262 wasn't developed immediately for interception operations, and thus took longer to get into service for that purpose.

Indeed, it was lucky for us that the entire German air war was on its knees by the time of the Me 262's introduction. Between a chronic lack of spare parts, fuel, trained pilots, and support infrastructure, the Me 262 could not be used to its full capability. The thing needed cover on its takeoff and landing cycles because it wasn't that maneuverable and took a while to perform either cycle. USAAF/RAF fighters got good at bouncing the 262 on its landing cycles, where it was largely defenseless.

I doubt that the course of the war in Europe would have been changed had the 262 been available earlier as an interceptor, but it certainly could have made our final victory much more expensive. A contrary view exists; apparently, the Eighth Air Force (and other heavy bombardment units) in the ETO were on the verge of cancelling operations at various points due to losses inflicted by the Luftwaffe's anti-aircraft artillery and fighters; with the 262 running around, the threshold for cancellation of the daylight effort might've been met, with unknown results for the war in Europe.

UPDATE, 23 JUNE 2005: The Superintendent of The Cold Spring Shops has a pleasant mention of this article, as does John over in the original TBG entry.

I'd like to revise and extend my remarks on the 262's shortcomings.

The primary problem with the Me 262 weapons system was its powerplant. This is not uncommon; the General Dynamics/Grumman F-111B died in part due to problems with the powerplant, and the Grumman F-14A Tomcat's TF30 powerplant was a piece of junk.

The 262 used the Junkers Jumo 004B turbojet engine as its powerplant; this was both good and bad. Good in that it was the first mass-produced jet engine, and bad for the same reasons. It personified Dr. Eldon Tyrell's (of Blade Runner fame) notion that "[t]he light that burns twice as bright burns half as long".

The 004B was a persnickety engine; software engineers might've called it a beta. For starters, it only had an operational life of 10-25 hours before the thing was ready for scrap or serious maintenance. I'm not sure what modern jet engines get, but you might burn up a pair of these things a week. That's not good.

Another problem with the 004B stemmed from the state of German metallurgy at the time; they couldn't mass-produce the kinds of metals necessary to make it a tough engine, and so they had to substitute lesser-quality materials for the manufacture of the turbine blades.

So it's got engines made by the lowest bidder. So what? So, you have to handle them accordingly.

Mishandling of the 004B---defined by rapid increases of the throttle---meant that the cheap turbine blades could break and be ingested by the rest of the engine. If you've seen The Phantom Menace, you know what happens when a pit droid (or a wrench tossed by Sebulba) goes into a pod racer's engine. This holds true on Earth as well; your engine becomes an expensive paperweight and you've got a potential fire on your hands. Additionally, the 004B did not spool up---provide additional power---easily. There was a fair amount of lag time between the pilot's advance of the throttle and the engine's response.

Keep these two facts in mind: It doesn't like to accelerate quickly and it takes its sweet time when you try.

What's this got to do with the takeoff and landing cycles, you say? Everything. Takeoff and landing will both require additional time, something the combat pilot doesn't always have.

The 262 required a decent takeoff roll and you had to be nice to the thing during the entire period, climbing away from the runway in a smooth manner while throttling back if possible, to keep the engines happy. Not necessarily fatal under ideal circumstances, but with the USAAF & RAF running around, you might not get to do this.

Worse yet was the landing sequence: The 262 pilot would get into position for landing, and essentially be stuck low, slow, and unable to accelerate off his approach if Mustangs or Thunderbolts showed up. You see the essential dilemma for the 262 pilot: He can't really run away from the battle in a hurry , and has to focus on getting to ground. That's not a very healthy strategy for survival, and it apparently accounted for a fair piece of the Me 262 losses.

Posted by: Country Pundit at 11:38 PM | No Comments | Add Comment
Post contains 825 words, total size 6 kb.